当前位置:首页-新闻中心新闻中心

空调山东通风管道清洗方法!

发布人:http://www.sftfgd.com   发布时间:2019-05-28 17:24:55

  空调山东通风管道清洗方法!

  Central air conditioning Shandong ventilation duct cleaning method!

  空调通风系统主要包括风管、新风风管、空调风箱、送风口、空气密封口、空气处理单元和风机盘管。空调系统在长期运行过程中容易发生积灰、堵塞等现象,造成微生物滋生、风阻、机组容量下降、压缩机耗电量增加等问题。解决这些问题根本的办法是彻底清洁空调通风系统。但是,如果清洗不符合规范的技术要求,通风管道内的灰尘、细菌和微生物将给周围环境、清洗人员、空调用户和空调设备带来极大的危害。

  The central air conditioning ventilation system mainly includes air duct, fresh air duct, central air conditioning bellows, air supply outlets, air sealing outlets, air handling units and fan coil units. Air conditioning system is prone to dust accumulation and blockage during long-term operation, which results in microbial breeding, wind resistance, unit capacity decline and compressor power consumption increase. The most fundamental way to solve these problems is to thoroughly clean the air conditioning and ventilation system. However, if cleaning does not meet the technical requirements of the specification, dust, bacteria and microorganisms in the ventilation duct will bring great harm to the surrounding environment, cleaning personnel, air conditioning users and air conditioning equipment.

  空调水系统清洗

  Cleaning of air conditioning water system由于空调管道内表面附着的主要是Ca2、Mg2、Fe2等化合物即为垢,属于中性。采用8‰~10‰中性除垢剂、缓蚀剂、镀液清洗三次。一个连续循环持续12小时,第二个连续循环持续6小时,第三个连续循环持续1小时。及时检测水质和水管表面状况。一般情况下清洗三次即可清洗干净,对长期未清洗的空调管道在清洗时应适当延长清洗时间。

  Because the inner surface of air-conditioning pipeline is mainly adhered to Ca2, Mg2, Fe2 and other compounds, that is, scale, belongs to neutral. Using 8 ~10 neutral scale remover, corrosion inhibitor, bath cleaning three times. The first continuous cycle lasts 12 hours, the second continuous cycle lasts 6 hours and the third continuous cycle lasts 1 hour. Inspect water quality and surface condition of water pipe in time. Normally, cleaning can be done three times, and the cleaning time should be prolonged appropriately for long-term uncleaned air-conditioning pipelines.

  冷却水系统清洗

  Cleaning of cooling water system

                   山东通风管道

  因为大多数的冷却水系统是开环系统,冷却水和长期暴露在空气中,二氧化碳,二氧化硫,二氧化氮,氧气在空气和其他气体溶于水和酸和强氧化性(如冷却水泵叶轮汽蚀现象发生),随着时间的推移,冷却水管,填料表面,水板形成一个包含嗜肺军团菌、b -溶血性链球菌,藻类,O2致病微生物如附件,管道腐蚀严重,环境污染(酸雨下冷却塔附近)。因此,如果使用酸性清洗剂,则使用5‰的弱酸除鳞剂、缓蚀剂、涂料溶液清洗三次,清洗程序如上。

  Because most cooling water systems are open-loop systems, cooling water and long-term exposure to air, carbon dioxide, sulfur dioxide, nitrogen dioxide, oxygen in air and other gases dissolved in water and acid and strong oxidation (such as cooling water pump impeller cavitation phenomenon occurs), over time, cooling water pipes, filler surface, water plate formed a containing Legionella pneumophila, B-hemolytic streptococcus, algae, O 2. Pathogenic microorganisms such as accessories, pipeline corrosion is serious, environmental pollution (near cooling tower under acid rain). Therefore, if acidic detergent is used, then 5 weak acid descaling agent, corrosion inhibitor and paint solution are used to clean three times. The cleaning procedure is as follows.

  通风系统清洗

  Ventilation system cleaning

  山东通风管道系统的清洗是清洗工作中的关键难点,因为通风管道一般都在天花板上,即使不在天花板上,因为管道是密封连接的,也很难清洗,经常采用机械清洗的方法。现在常见的清洗方法的帆布软连接装置将在通风管道检测机器人或气动机器人,通过管道机器人控制箱控制,通风管道清洁机器人,尘含量多的管道系统使用管彻底垃圾收集器的收集管,以防止二次污染。

  The cleaning of Shandong ventilation pipeline system is the key difficulty in cleaning work, because the ventilation pipeline is usually on the ceiling, even if not on the ceiling, because the pipeline is sealed and connected, it is difficult to clean, and mechanical cleaning method is often used. Nowadays, the common cleaning method of canvas soft connection device will detect robots or pneumatic robots in ventilation pipes, control them through the control box of the pipeline robot, clean the ventilation pipes, and use the collecting pipes of the exhaustive garbage collector in the dust-rich pipeline system to prevent secondary pollution.

  表的冷却、加热、加湿器的表面、冷凝盘的表面,回风口清洗表的冷却、加热、加湿器,回风口清洗不仅能改善空气质量,而且具有较强的效果。常用的清洗方法是使用空气射流清洗剂,然后用高压水或空气进行清洗,使污物迅速溶解并被冲走,然后用低压水冲洗干净。附着在表面冷却器表面的污染物含有溶血性链球菌等致病微生物,大部分翅片清洗后进入冷凝水板,长期积累会对水板造成二次污染,并伴有异味。因为这个冷凝盘是清洗过的,也不能忽视。常用的冷凝盘清洗方法是在冷凝盘上喷洒清洗剂,然后用清水冲洗。

  Cooling, heating, humidifier surface, condensation plate surface, cooling, heating and humidifier of return air outlet cleaning table, return air outlet cleaning can not only improve air quality, but also have a strong energy-saving effect. The common cleaning method is to use air jet cleaning agent, and then use high-pressure water or air to clean, so that the dirt quickly dissolved and washed away, and then washed with low-pressure water. Contaminants attached to the surface of the cooler contain pathogenic microorganisms such as Streptococcus haemolyticus. Most of the fins are washed and enter the condensate plate. Long-term accumulation will cause secondary pollution of the water plate, accompanied by odor. Because this condensation plate has been cleaned and can not be ignored. The common cleaning method of condensation plate is spraying cleaning agent on the condensation plate, and then rinsing with clean water.

  空调山东通风管道清洗方法!以上是空调冷水机组水系统和通风系统的清洗方法。只有关注空调系统的管理,及时清理和维护,才能确保空调设备和设施处于良好状态,增加了生活的各种各样的设备和设施,确保设备的正常和运行。

  Central air conditioning Shandong ventilation duct cleaning method! The above is the central air conditioning chiller water system and ventilation system cleaning method. Only by paying attention to the management of the central air-conditioning system and timely cleaning and maintenance, can we ensure that the central air-conditioning equipment and facilities are in good condition, increase all kinds of equipment and facilities in life, and ensure the normal and safe operation of the equipment.


上一篇:济南黑白铁加工质量怎么样
下一篇:通风管的消声器技术原理你知道吗

网站首页 关于我们 产品展示 新闻中心 工程案例 在线留言 联系我们