如何清洗山东通风管道内乱七八糟的东西?

发布人：http://www.sftfgd.com   发布时间：2019-06-06 17:09:44

　　如何清洗山东通风管道内乱七八糟的东西?

　　How to clean the messy things in Shandong ventilation pipeline?

　　持续增长的通风管的使用时间,它会积累大量的杂质,这些杂质将存储在管很长一段时间,在操作将加快石油凝结,温度高,构成气动阀的损坏,液压和其他组件,在正常运行构成很大的影响。因此，有必要定期对通风管道设备进行清洗。你怎么清理它?山东通风管道为您介绍如下:

　　With the increasing use time of ventilation pipe, it will accumulate a large amount of impurities, which will be stored in the pipe for a long time. The operation will speed up the condensation of oil, high temperature, the damage of pneumatic valve, hydraulic and other components, which will have a great impact on the normal operation. Therefore, it is necessary to regularly clean ventilation pipeline equipment. How do you clean it? Shandong Ventilation Pipeline Expert will introduce you as follows:

　　(1)风管与风机连接时，应在出风口的进、出口处加软接头。软接头的截面尺寸应与风机的进、出口截面尺寸相同。软管接头可由帆布、人造革等材料制成。软管长度不应小于200，密封性应适当。柔性软管可以缓冲风机的振动。

　　(1) When connecting the air duct with the fan, soft connectors shall be added at the inlet and outlet of the air outlet. The cross-section size of the soft joint should be the same as that of the inlet and outlet of the fan. The hose joint can be made of canvas, artificial leather and other materials. The length of hose should not be less than 200 and the sealing should be appropriate. Flexible hose can cushion the vibration of fan.

　　(2)风管与除尘设备、加热设备连接时，根据理论制图，在设备和设备结束后，应暂停预制和设备。

　　(2) When the air duct is connected with dust removal equipment and heating equipment, according to the theoretical drawing, the prefabrication and equipment shall be suspended after the end of the equipment and equipment.

　　(3)济南通风管道安装时，进、出口风量天应在预制的开孔风道内，如果出风口在设备上风道的末端，则其接口应严密。

　　(3) When installing Jinan ventilation pipeline, the air volume of inlet and outlet should be in the prefabricated open air duct every day. If the outlet is at the end of the air duct on the equipment, its interface should be tight.

　　(4)输送含冷凝水或含水量较大的气体时，水平管道应设置坡度，并在低点与排水管道连接。安装设备时，管道底部不应存在纵向接缝。

　　(4) When conveying gas containing condensate water or high water content, the horizontal pipeline should be gradient and connected with the drainage pipeline at the lowest point. When installing equipment, there should be no longitudinal joints at the bottom of the pipeline.

　　(5)输送易燃易爆气体的钢板风道，在风道连接法兰处安装跳线，并与静电接地网连接。

　　(5) The steel plate air duct for conveying flammable and explosive gases shall be connected with the electrostatic grounding grid by installing jumpers at the connecting flange of the air duct.

　　(6)水平风道高度在4m以上时，安装人员应系好带。脚手架或移动式脚手架在舷梯上应固定好，舷梯宽度应符合规范，脚手架上的设备人员应随身携带包袋，避免东西或电钻等掉落物受伤。

　　(6) When the height of horizontal duct is more than 4m, the installer should fasten the seat belt. Scaffolds or mobile scaffolds should be fixed well on the gangway, the width of the gangway should conform to safety standards, and equipment personnel on the scaffolding should carry bags with them to avoid injuries to falling objects such as things or electric drills.

　　(7)风管就位后，双吊臂支撑应保证水平臂伸直，吊臂保持不变，双吊臂受力均匀。

　　(7) After the air duct is in place, the support of double booms should ensure that the horizontal arm is straight, the boom remains unchanged, and the force of the double booms is uniform.

　　山东通风管道好每三个月清洗一次，既能保证正常运行，又能延长通风管道的使用寿命。如果您不明白清洁的问题，请到我们的网站电话咨询，我们会及时回复您!

　　Shandong ventilation pipeline should be cleaned every three months, which can not only ensure normal operation, but also prolong the service life of the ventilation pipeline. If you do not understand the problem of cleaning, please call our official website for consultation, we will reply to you in time!