厨房排烟那为什么需要定期清洗呢

发布人：http://www.sftfgd.com   发布时间：2022-12-26 18:55:09

济南酒店厨房排烟工程在酒店、食堂中是很重要的。厨房排烟工程定期就需要清洗。那为什么需要定期清洗呢，一起来了解一下吧。
The kitchen smoke exhaust project of Jinan Hotel is very important in hotels and canteens. The kitchen smoke exhaust works need to be cleaned regularly. Why do you need to clean it regularly? Let's find out.
我们知道排烟系统是由烟罩、烟室、横烟道、竖烟道、油烟分离净化器、风机组成的， 烟罩位于灶台之上，一般由不锈钢和白铁皮制成，下面炒菜时，油烟四处弥漫，但因为开着风机，烟雾就直接聚拢在烟罩内从吸风口进入烟室了。日久天长，烟罩上就吸附了大量的油污。油水混合物其顺着烟室往厨师头上、身上滴，严重时就像下雨一样连绵不绝。这种情况是特别危险的。
We know that the smoke exhaust system is composed of a smoke hood, a smoke chamber, a horizontal flue, a vertical flue, an oil smoke separator and a fan. The smoke hood is located on the stove and is generally made of stainless steel and white iron sheet. When cooking below, the oil smoke is diffused everywhere, but because the fan is turned on, the smoke directly gathers in the smoke hood and enters the smoke chamber from the air intake. After a long time, a lot of oil stains are adsorbed on the hood. The mixture of oil and water drips onto the head and body of the chef along the smoke room. In severe cases, it is like rain. This situation is particularly dangerous.

通风位置尽可能高，是吸顶安装，风道同样是越短越好，减少管道阻尼噪音。依据上述要求可以保证抽油烟机和排风机工作时低噪音（噪音小于55分贝的标准）；通风换气效果达到设计能力。
The ventilation position should be as high as possible. It should be ceiling mounted. The shorter the air duct is, the better, so as to reduce the damping noise of the pipe. According to the above requirements, it can ensure that the range hood and exhaust fan can work with low noise (the national standard of noise less than 55 decibels); The ventilation effect shall reach the design capacity.
济南厨房排烟道的走法有5种，要看实际情况适合哪一种百了，一：在顶棚里面预埋直径160MM的PCV管，放在烟度机设计位置的上方。第二：在吊柜顶部与厨房顶棚之间的空隙走，吊柜前面需要设计封板遮挡。知第三在烟机二层挡板后面直接走背墙，这样的一半是别墅才能实现。第四：老式房子，没用公用烟道的，烟机在飘窗上，烟机管走窗户玻璃道。第五：厨房高度吊顶后低于2300，一种第二种方法无法实现，烟机管在吊柜里穿过吊柜侧板进入共用烟道专。烟机烟道的的设计直接影响到烟机的排烟效果和整体厨房外观的效果，建议采用一属、第二种方式。
There are five ways to walk the exhaust flue in Jinan kitchen, depending on the actual situation. First, a 160mm diameter PCV pipe is embedded in the ceiling and placed above the design position of the smoke detector. Second: walk in the gap between the top of the wall cabinet and the kitchen ceiling, and the front of the wall cabinet needs to be covered by a sealing plate. Zhidi walks directly behind the second baffle of the flue gas turbine on the back wall, so that half of it can be realized by villas. Fourth: Old style houses do not use public flue. The flue gas machine is on the window, and the flue gas pipe goes through the window glass channel. Fifth: The height of the kitchen ceiling is lower than 2300, and the second method cannot be realized. The flue gas pipe enters the common flue through the side plate of the wall cabinet in the wall cabinet. The design of the flue of the flue gas turbine directly affects the smoke exhaust effect of the flue gas turbine and the overall appearance of the kitchen. It is recommended to adopt the first and second methods.
通常油烟净化器在使用一段时间后就要进行清洗，如果油污过多就会导致里面电场阻塞，油烟净化器无法正常进行工作，大大降低净化效率。一旦被举报还要面临停产整改，增加大量额外支出，更严重的是万一引发火灾，就会危及到人的生命财产。
Usually, the lampblack purifier needs to be cleaned after a period of use. If there is too much oil, the electric field inside will be blocked, and the lampblack purifier cannot work normally, which greatly reduces the purification efficiency. Once reported, the company will also face shutdown rectification, which will increase a lot of additional expenses. More seriously, in case of a fire, it will endanger the safety of people's lives and property.
以上就是为大家介绍的有关济南铁皮风管加工的详细的介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以的态度,为您提供服务http://www.sftfgd.com
The above is a detailed introduction to the processing of Jinan iron sheet air duct, and I hope it will be helpful to you. If you have any questions, please contact us. We will provide you with our attitude http://www.sftfgd.com